投稿指南出版伦理版权说明 我要投稿
首页 > 过刊浏览>2010年第29卷第4期 >572-577
PDF HTML阅读 XML下载 导出引用 引用提醒
乳酸丙二醇酯的非水相酶催化合成及应用研究
DOI:
作者:
作者单位:

作者简介:

通讯作者:

中图分类号:

基金项目:

国家烟草专卖局科技项目(110200701004)


Studies on Lipase-Catalyzed Synthesis of Propanediol Lactate in Non-aqueous Phase and its Application
Author:
Affiliation:

Fund Project:

  • 摘要
    • |
  • 图/表
    • |
  • 访问统计
    • |
  • 参考文献
    • |
  • 相似文献
    • |
  • 引证文献
    • |
  • 资源附件
    • |
  • 文章评论
    摘要:

    以乳酸和丙二醇为原料,以一种固定化的假丝酵母脂肪酶为催化剂,催化合成了乳酸丙二醇酯,并对比了乳酸、丙二醇和乳酸丙二醇酯的保湿性和吸水性。研究确定的最优反应条件为:50 mL正己烷为溶剂,初始乳酸浓度为0 mol/L,丙二醇浓度为0.4 mol/L,加入固定化脂肪酶0.2 g,ZGS高效耐酸分子筛添加量2.0 g,反应温度50℃,以0.01 mol/(L.h)的速度滴加脱水乳酸20 h,搅拌催化反应,反应64 h结束,乳酸转化为乳酸丙二醇酯的酯化率达到97.3%。反应后纯化得到的产品质谱分析和红外光谱分析结果证实为乳酸丙二醇酯,GC质量分数达到99%以上。乳酸丙二醇酯的保湿性和吸水性试验表明:在相同的温度和湿度条件下,乳酸丙二醇酯的保湿效果比乳酸和丙二醇好,吸水性与丙二醇相当。乳酸丙二醇酯应用到卷烟中,可增加烟气舒适度,降低烟气干燥感。

    Abstract:

    The study synthesized a propanediol lactate with lactic acid and propylene glycol as substrate and catalyst by an immobilized Candida rugosa lipase.as catalyst and compared the moisture absorption and water absorption of lactic acid、propylene glycol and propanediol lactate.The optimum reaction conditions were determined and listed as follows: The reaction was stirred at 50 ℃ with hexane as solvent,0 g/L initial lactic acid concentration and then feed at 0.01mol/L for 20 h,0.4 mol/L propylene glycol concentration,0.2 g/L immobilized lipase,2.0 g/L molecular sieve,and the reaction time is 60 h.With this optimum conditions,the conversion percent of lactic acid to propanediol lactate was achieved at 97.3%.The purified product after reaction was proved as propanediol lactate by MS and infrared spectrum analysis which content was above 99%.Then the moisture absorption and water absorption of lactic acid,propylene glycol and propanediol lactate were compared and the results shown that the effect of moisture absorption of propanediol lactate was better than that of lactic acid and propylene glycol,respectively.The effect of water absorption was the same as that of propylene glycol in the same temperature and humidity condition.Propanediol lactate was used as cigarette additive.The smoke was comfortable and the dry sensation was reduced.

    参考文献
    相似文献
    引证文献
引用本文

姜兴涛,刘强,李庆廷,李智宇,李锐,侯春,于铁妹.乳酸丙二醇酯的非水相酶催化合成及应用研究[J].食品与生物技术学报,2010,29(4):572-577.

JIANG Xing-tao, LIU Qiang, LI Qing-ting, LI Zhi-yu, LI Rui, HOU Chun, YU Tie-mei. Studies on Lipase-Catalyzed Synthesis of Propanediol Lactate in Non-aqueous Phase and its Application[J]. Journal of Food Science and Biotechnology,2010,29(4):572-577.

复制
分享
文章指标
  • 点击次数:
  • 下载次数:
  • HTML阅读次数:
  • 引用次数:
历史
  • 收稿日期:
  • 最后修改日期:
  • 录用日期:
  • 在线发布日期: 2014-06-17
  • 出版日期:
文章二维码

版权所有：《食品与生物技术学报》编辑部

地址：江苏省无锡市蠡湖大道1800号  邮政编码：214122

电话：0510-85913526  电子邮件：xbbjb@jiangnan.edu.cn

技术支持：北京勤云科技发展有限公司

微信公众号二维码

手机版网站二维码