两相厌氧耦合生物脱硫组合工艺处理糖蜜乙醇废水的性能

doi:10.3969/j.issn.1673-1689.2017.03.004

首页 > 过刊浏览>2017年第36卷第3期 >252-258. DOI:10.3969/j.issn.1673-1689.2017.03.004

两相厌氧耦合生物脱硫组合工艺处理糖蜜乙醇废水的性能
DOI:
                        10.3969/j.issn.1673-1689.2017.03.004
                    
作者:
                        
                        
                    
作者单位:
作者简介:
通讯作者:
中图分类号:X703
基金项目:

Treatment of Molasses-Alcoholic Wastewater via A Two-Stage Anaerobic Process Combined with Biological Desulfurization

Author:

Affiliation:

Fund Project:

摘要

图/表

访问统计

参考文献

相似文献

引证文献

资源附件

文章评论

摘要:

采用两相厌氧耦合生物脱硫组合工艺处理糖蜜乙醇废水，在启动和运行过程对各处理单元的效能进行了测定分析。结果表明，当进水COD和SO42-负荷提升至18~21 kg/（m3·d）和0.8~1.1 kg/（m3·d）时，组合工艺的COD和SO42-去除率可分别达到95%~96%和86%~90%，出水中COD、SO42-和硫化物含量分别为6 000~6 500、800~850、750~800 mg/L。从各处理单元的运行效能来看，一级厌氧和二级厌氧对COD去除的贡献率分别为86%和11%，同时两者对硫酸盐去除的贡献率分别为90%和7%；而生物脱硫贡献率较小，均在3%左右。由此可见，一级厌氧的处理效能要显著高于二级厌氧。此外生物脱硫单元在高负荷运行条件下的硫化物去除率较低（30%左右），增加曝气量虽然一定程度上可以增加溶氧以及缓解单质硫在陶粒表面的吸附，但同时也可能会影响生物膜的形成和硫细菌的固定，从而造成微生物大量流失。因此如何保证氧气、底物与硫细菌之间的高效传质将是今后需要进一步解决的关键问题之一。

Abstract:

The operation performance of a process including two-stage anaerobic digestion combined with biological desulfurization for treating molasses alcohol wastewater was evaluated during the startup and stable operation in this study. The results showed that when the COD and SO42- volume loading rate were improved to 15~21 kg/（m3·d） and 0.8~1.1 kg/（m3·d），the removal rate of COD and SO42- were up to 95%~96% and 86%~90%，respectively，and the content of COD，SO42- and sulfide in effluent were 6 000~6 500，800~850 and 750~800 mg/L，respectively. Especially，the contribution rates to the COD and SO42- remove efficiencies for the first stage and the second stage digestion were 86%，11% and 90%，7%，respectively，while both of them were about 3% in the biological desulfurization. Thus，the treatment efficiency of the first stage digestion was significantly higher than that of the second stage digestion. Furthermore，the sulfide remove rate was relatively low（about 30%） in the biological desulfurization process under high loading rate. Although it was possible to increase dissolved oxygen and relieve the adsorption of sulfur on the ceramic surface by improving aeration strength，the increasing aeration also affected the formation of biofilm and fixation of sulfur bacteria，which led to the loss of microorganisms. Hence，how to ensure mass transferring efficiently among the substrate，sulfur bacteria and oxygen was the key problem to be solved in the further research.

参考文献

相似文献

引证文献

引用本文

李亚东,肖小兰,黄振兴.两相厌氧耦合生物脱硫组合工艺处理糖蜜乙醇废水的性能[J].食品与生物技术学报,2017,36(3):252-258.

LI Yadong, XIAO Xiaolan, HUANG Zhenxing. Treatment of Molasses-Alcoholic Wastewater via A Two-Stage Anaerobic Process Combined with Biological Desulfurization[J]. Journal of Food Science and Biotechnology,2017,36(3):252-258.

复制

文章指标

点击次数:
下载次数:
HTML阅读次数:
引用次数:

历史

收稿日期:
最后修改日期:
录用日期:
在线发布日期: 2017-04-28
出版日期:

文章二维码

地址：江苏省无锡市蠡湖大道1800号邮政编码：214122

电话：0510-85913526 电子邮件：xbbjb@jiangnan.edu.cn

技术支持：北京勤云科技发展有限公司

引用本文

分享

文章指标

历史

文章二维码

微信公众号二维码

手机版网站二维码